3. PROCEDIA.pdf - Acidogenesis of Palm Oil Mill Effluent to Produce Biogas: Effect of Hydraulic Retention Time and pH

(1)

 All sources 56  Internet sources 26  Own documents 9  Organization archive 2

[17]  "5. IJSE 1.pdf" dated 2017-12-07

1.5% 7 matches

[26]  "6. IJSE 2.pdf" dated 2017-12-07

1.2% 5 matches

[30]  "26. Full Paper to Intl Conference.doc" dated 2017-12-07

0.7% 5 matches

Results of plagiarism analysis from 2017-12-07 09:03 UTC

3. PROCEDIA.pdf

(2)

[43]  "19. JTKU.pdf" dated 2017-12-07

0.6% 2 matches

[44]  https://www.scribd.com/document/28171138...sophilic-temperature

0.6% 1 matches

[45]  "33. Paper Maestruct an Dr. Irvan.doc" dated 2017-12-07

0.4% 2 matches

[46]  www.academia.edu/13641506/Anaerobic_acid...sophilic_temperature

0.4% 1 matches

[47]  https://www.researchgate.net/publication...cess_During_Start-up

0.3% 1 matches

[48]  "#530-Arifiyanto et al (ARPN JEAS)final.docx" dated 2017-07-10

0.3% 1 matches

[54]  "3836 - FINAL.doc" dated 2017-09-25

0.2% 1 matches

162 matches from 58 sources, of which 42 are online sources.

Settings

Data policy: Compare with web sources, Check against my documents, Check against my documents in the organization repository, Check against organization repository, Check against the Plagiarism Prevention Pool

Sensitivity: Medium Bibliography: Consider text

(3)

--Procedia - Social and Behavioral Sciences 195 ( 2015 ) 2466 – 2474 [28]

Available online at www.sciencedirect.com

Acidogenesis of Palm Oil Mill Effluent to Produce

Biogas:

Effect of Hydraulic Retention Time and pH

[22]

Bambang Trisakti

a

*, Veronica Manalu

a

, Irvan Taslim

a

, Muhammad Turmuzi

a

Chemical Engineering Department, University of Sumatera UtaraJalan Almamater Komplek USU, Medan 20155, Indonesia

Abstract Abstract

Acidogenesis of palm oil mill effluent to produce biogas was conducted base on anaerobic digestion process[. 23This process was]

consisted of four different stages using various types of microorganisms which came from various groups of bacteria. This [23]

research studied the effect of hydraulic retention time (HRT) and pH to the change of the organic compounds concentration and solids content of POME to the growth of microorganisms during acidogenesis stage. [29Initially, the suitable loading up was ] determined by varying the HRT 6.7; 5.0; and 4.[230 days ] in the continuous stirred tank reactor (CSTR) with mixing rate 50 rpm, pH 6.0 ± 0.2, and room temperature. Next, suitable pH was determined by varying the pH at 5.0; 5.5; and 6.0 with mixing rate 100-110 rpm and temperature 55oC. Analysis of TS, VS, TSS, VSS, COD, and VFA were conducted in order to study the growth of microorganisms and their abilities in converting organic compound to produce VFA. The highest growth of microorganisms was achieved at HRT 4.0 day with microorganism concentration was 20.62 mg VSS/L and COD reduction was 15.7%.[20The ] highest production of total VFA achieved was 5622.[2072 mg/L at pH 6] [.200, with the concentration of acetic acid] , propionic acid and butyric acid were 2257.34; 975.49; and 2389.90 mg/L, respectively. While degradation VS and COD were 11 and 23%, respectively.

Peer-review under responsibility of Istanbul University.

[28]

Keywords: acidogenesis; anaerobic digestion; biogas; POME

* Corresponding author. Tel.: +62-812-6362-2066; fax: +62-61-821-3250.

E-mail address: b_trisakti@yahoo.com

(4)

2467

Bambang Trisakti et al.[2 / 8]Procedia - Social and Behavioral Sciences 195 ( 2015 ) 2466 – 2474

1.

1. Introduction [ Introduction 448]

Indonesia is currently the largest producer of palm oil in the world with a total production reached 33 million tons

(USDA FAS, 2015). Palm oil is produced from approximately 8.54 million hectares of oil palm plantations (Wright

& Rahmanulloh, 2015), which mostly located on the island of Sumatra and Borneo (Jaenicke et al., 2008). The process to extract oil requires significantly large amounts of water for steam sterilization of fresh palm fruit bunches (FFB) and clarification of extracted oil. As a result, palm oil mill (POM) produces large amounts of wastewater or commonly called palm oil mill effluent (POME). For every ton of FFB processed will produce approximately 0.6 to 0.87 m3 POME or 2.4 to 3.7 tons of POME per one ton of palm oil produced (Alam, Jamal, & Nadzir, 2008; O-Thong, Boe, & Angelidaki, 2012). POM also generates large amount of solids wastes such as empty fruit bunch (EFB) (23%), shell (5%), and mesocarp fiber (12%) for every ton of FFB processed in the mills (O-Thong, Boe, & Angelidaki, 2012).

Most of the existing POME processing in POMs is anaerobic-aerobic lagoon system (Wu, Mohammad, Jahim, & Anuar, 2010). This system aims to reduce waste pollution parameters before being discharged into water bodies or for land application (Lam & Lee, 2011).[17 POME as feedstock utilization of biogas (CH] 4, CO2, H2S, etc.) through the

[21]

process of anaerobic digestion has been widely reported by the researchers, even has been applied on a commercial scale in several POMs in Malaysia and Indonesia (Hosseini & Wahid, 2013). POME conversion into biogas would provide more benefits because this process in addition will reduce waste pollution parameters such as organic solids, microbial pathogens, and toxicity.[20 Furthermore, this technique will also produce biogas which can be used as an ] alternative energy (Stamatelatou, Antonopoulou, & Lyberatos, 2011). Although it has been applied on a commercial [21] scale, but the hydraulic retention time (HRT) is still high enough so that the investment needed to build this process is high (Yingyuad, 2007). [34]

Anaerobic digestion is a biochemical process without the presence of oxygen which complex organic compounds are broken down by different types of anaerobic bacteria (Seadi et al., 2008). This process involves a four-step process that engages four different types of bacterial groups (hydrolysis, acidogenic, acetogenic, and methanogenic). Each of these bacteria have a different physiology and nutritional requirements (Olvera & Lopez, 2012). If all four groups of bacteria are working under the same conditions, there will be an imbalance between the formations of acid and methane that biogas production time will be longer (Jung et al., 2000). In an effort to accelerate the rate of biogas production, many researchers separate the anaerobic digestion process into two stages (Jung et al., 2000). In the first stage, the organic compounds contained in POME are converted into compounds of volatile fatty acids (VFA) by hydrolysis, acidogenesis, and acetogenesis (commonly referred as acidogenesis stage) and subsequently the VFA is converted into biogas through methanogenesis stage (Wong et al., 2013). Therefore, to improve the effectiveness of the two-stage anaerobic digestion process, the optimum operating conditions such as pH, temperature, and agitation rate of each of the stages should be known (Veeken et al., 2000; Polprasert, 2007). This paper will report the effect of variations of HRT and pH on the acidogenesis stage.

2.

2. Literature Review Literature Review

(5)

2468 Bambang Trisakti et al. / Procedia - Social and Behavioral Sciences 195 ( 2015 ) 2466 – 2474

(Na), calcium (Ca), iron (Fe), zinc (Zn), chromium (Cr), and others (Salihu & Alam, 2012). Therefore, POME can be utilized as substrates and nutrients for microorganisms in methanogenic anaerobic digestion for biogas production (Seadi et al., 2008).

Fig. 1. Indonesia's palm oil production growth in 2004-2014 (Source:[21 Wright & Rahmanulloh, 2015) ]

Methanogenic anaerobic digestion is anaerobic bioconversion process that actually has been practiced for a long time and has also been applied on a commercial scale. This process is complicated because it involves a mixed population of microorganisms and produces various gases and fluids, so it requires accurate process control and product purification (Li & Yu, 2011). As a comparison, a two-stage process of anaerobic digestion, which separates the stage acidogenesis and methanogenesis stages, is allowing for more flexible operations. Furthermore the amount and purity of the product is higher (Blonskaja, Menert, & Vilu, 2003;. Demirer & Chen, 2005).

Some researchers report that the methanogenesis stage takes place at a neutral pH range, with optimum ranges between 7-8, while microorganisms acidogenesis generally are optimum at lower pH (Seadi et al., 2008). Environmental factors that influence the acidogenesis stages are substrate, inoculum, pH, temperature, and HRT (He et al., 2012). Low pH and short HRT are conditions favored by acid-forming bacteria to grow and may inhibit the growth of microorganisms forming methane (Solera, Romero, & Sales, 2002).[18 High alkalinity is often necessary to ]

maintain the pH in connection with high CO2 content in the biogas (Zhang, 2014).

Control of HRT is needed to help multiply the microorganisms of hydrolysis and acidogenesis (Fang and Yu, 2000) and will increase the production of VFA (Maharaj & Elefsiniotis, 2001).[49 Retention time should be long ] enough to ensure the number of dead microorganisms in the digester is not higher than the amount of reproduced microorganisms (Seadi et al., 2008)

3. Methodology 3. Methodology

3.1. Research Goal

(6)

2469

Bambang Trisakti et al. / Procedia - Social and Behavioral Sciences 195 ( 2015 ) 2466 – 2474

3.2.[2 Materials, Experimental set-up, and Data Collection 7]

x Materials

Fresh POME was collected from a fat pit of Adolina POM, Sumatera Utara, Indonesia, and stored in 300 L clean

high-density polyethylene (HDPE) container. It was transported to the laboratory, mixed well, put in 1-liter plastic

bottles, and stored at 4 °C until further use.[54 Fresh POME characteristics are shown in Table 1.] Acidogenic bacteria as starter were collected from acidification pond of WWTP of POM at Torgamba, Sumatera Utara, Indonesia. Sodium bicarbonate (NaHCO3) was used as pH adjusting.

Table 1. Characteristics of fresh POME

Parameters Units Results Methods

pH - 3.70 – 4.70

Chemical Oxygen Demand (COD) mg/L 48,300 APHA 5220B

Total Solid (TS) mg/L 13,420 – 37,020 APHA 2540B

Volatile Solid (VS) mg/L 10,520 – 31,220 APHA 2540E

Total Suspended Solid (TSS) mg/L 2,080 – 27,040 APHA 2540D

Volatile Suspended Solid (VSS) mg/L 1,920 – 25,800 APHA 2540E

Oil and Grease mg/L 6.25 APHA 5520B

Protein % 0.[53 23] Kjeldahl

Carbohydrate % trace Lane Eynon

x Experimental set-up

The laboratory scale of continuous stirred tank reactor (CSTR) as fermenter is shown in Figure 2. The CSTR is

EYELA model MBF 300ME with working volumes is 2 L. The fermenter comprises an integrated on-line temperature and pH data recording system. No pH adjustment was applied to the fermenter. However, pH of the raw POME was controlled with sodium bicarbonate (NaHCO3), then after that, fed into the fermenter.

(7)

x Data Collection

Data collected during the experiment were pH, alkalinity, TS, VS, TSS, VSS, COD, and VFA which according to the American Public Health and Association (APHA) standard methods for water and wastewater (APHA, 1999) as presented in Table 2.

Table 2. Analysis methods of data collection (APHA, 1999)

Parameters Units Methods

pH -

Alkalinity mg/L APHA 2320B

Total Solid (TS) mg/L APHA 2540B

Volatile Solid (VS) mg/L APHA 2540E

Total Suspended Solid (TSS) mg/L APHA 2540D

Volatile Suspended Solid (VSS) mg/L APHA 2540E

Chemical Oxygen Demand (COD) mg/L APHA 5220B

Volatile Fatty Acids (VFA) mg/L APHA 5560B

3.3. Results and Discussion

x Effect of hydraulics retention time (HRT)

Microbial adaptation and growth of the starter were carried out by reducing the HRT or organic loading up. During loading up, HRT was reduced slowly and evaluated at HRT 6.7; 5.0; and 4.0 days. The fermenter was controlled at room temperature, mixing rate 50 rpm, and the pH was kept constant at 6 (± 0.2). The experiment was conducted in intermittent operation mode, where fresh feed and effluent where flown in every 4 hours or 6 times per 24 hours. pH was maintained by adding sodium bicarbonate (NaHCO3) in the fresh feed. pH, alkalinity, TS, and VS

of the feed and effluent were analyzed every day, while the TSS, VSS, COD and VFA were analyzed after the stable data was achieved. The results of experiments on organic loading up are presented in a graph showing the effect of HRT reduction on pH and alkalinity, also the microbial growth, and COD reduction.

The effect of HRT reduction on pH and alkalinity is presented in Figure 3. The pH value slightly fluctuates but remains constant at 6 days because the addition of sodium bicarbonate in the feed. As a result, large fluctuation in the value of alkalinity occurred, although it is still in the range where the acidogenesis process takes place i.e. in the range of 542 - 3580 mg/L (Senthil Kumar 2010; Schmit & Ellis, 2001)

Figure 3. Effect of HRT reduction on pH and alkalinity

(8)

2471

Effect of HRT reduction on microbial growth is described by the change of VSS concentration in the fermenter. Metabolism and growth of microbial are also highly dependent on the pH and alkalinity (SenthilKumar 2010; Schmit & Ellis, 2001). Figure 4 shows VSS profile simultaneously with the pH and alkalinity during the process. The pattern of microbial growth is significantly influenced by changes in pH and alkalinity. The highest concentration of microbes achieved at HRT 4 days was 20.62 mg VSS/L, although at this is the shortest HRT.

Figure 4. Effect of HRT reduction on microbial growth

Effect of reduction HRT on microbial growth can also be explained by the amount of COD decrease in inlet and outlet of the fermenter as shown in Figure 4. Although the decrease of COD indicates the occurrence of microbial growth but the expected decrease COD is not too large, because the desired product of acidogenesis process is VFA.

Figure 5. Effect of reduction of HRT on COD reduction

x Effect of pH

Effect of pH on acidogenesis process was studied by conducting a series of experiments by varying the pH at 5.0; 5.5; and 6.0, mixing rate at 100 rpm, temperature of 55 °C, and HRT 4 days. The experiment was conducted in intermittent operation mode, where fresh feed and effluent where flown in every 4 hours or 6 times per 24 hours. The pH was maintained by adding sodium bicarbonate (NaHCO3) in the feed. The pH, alkalinity, TS, and VS from

(9)

Effect of pH on alkalinity and microbial growth are presented in Figure 6. At the beginning of pH 5.0 the alkalinity is decreased, because the pH of fresh POME is 4.7 and thus the addition of sodium bicarbonate in feed is only small. After day 10, alkalinity started to rise and eventually fluctuated at 3000 mg/L. Similarly, the growth of microbes, although initially decreased but from day 10 to be stable in the range of 12000-16000 mg/L.

Figure 6. Effect of pH on (a) alkalinity and (b) microbial growth

Effect of pH on VS and COD reduction is presented in Figure 7. Both graphs are actually used to look for microbial activity. VS and COD reduction is best achieved at a pH of 5.5 for the reduction is not too large.

Figure 7. Effect of pH on (a) VS reduction and (b) COD reduction

Effect of pH on VFA production is presented in Figure 8 (a) while its effect on the VFA alkalinity ratio is presented in Figure 8 (b). VFA production is expressed with the production of acetic acid, propionic acid, and butyric acid. Although the VFA production was highest at pH 5.[400, but high production of propionic acid, if the ]

amount is greater than 1500 mg/L, its presence will disrupt next stage (methanogenesis) (Senthilkumar et al., 2010).

Thus, the highest VFA production are at pH 6 but considering the VS and COD reduction (Figure 7), then the VFA

[40]

production is best at pH 5.5. The VFA alkalinity ratio (Figure 8b) is to describe the stability of process acidogenesis

where it is assumed stable if the VFA alkalinity ratio is greater than one (Li et al., 2012).

a b

(10)

2473

Figure 8. Effect of pH on (a) VFA production and (b) VFA Alkalinity ratio

4.

4. Conclusion Conclusion

On the loading up process, the highest growth of microorganisms was achieved at HRT 4.0 day with microorganism concentration was 20.62 mg VSS/L and COD reduction was 15.7%.[20 Meanwhile, on the pH variation, ] the highest production of total VFA achieved was 5622.72 mg/L at pH 6.0, with the concentration of acetic acid, propionic acid and butyric acid were 2257.34; 975.49; and 2389.90 mg/L, respectively. While degradation VS and COD were 11 and 23%, respectively.

Acknowledgements Acknowledgements

This research was supported by Penelitian Desertasi Doktor No. 4800/UN5.1.R/KEU/2014, date June 23, 2014.

References References

USDA FAS. (2015). Oilseeds: Markets and Trade. April 2015. (pp. 16). (http://apps.fas.usda.gov/psdonline/circulars/oilseeds.pdf).

Wright, T., & Rahmanulloh, A. (2015). Oilseeds and Products: Annual Report 2015. GAIN Report. (pp. 2-4). Jakarta: USDA Foreign Agricultural Service.

Jaenicke, J., Rieley, J.O., Mott, C., Kimman, P., & Siegert, F. (2008). Determination of the amount of carbon stored in Indonesian peatlands.

Journal Geoderma, 147, 151–158.

[24]

Alam, M. Z., Jamal, P., & Nadzir, M. M. (2008). Bioconversion of palm oil mill effluent for citric acid production: statistical [24] optimization of fermentation media and time by central composite design.World J Microbiol Biotechnology, 24, 1177–1185.

O-Thong, S., Boe, K., & Angelidaki, I. (2012). Thermophilic Anaerobic Co-digestion of Oil palm Empty Fruit Bunches with Palm Oil Mill Effluent for Efficient Biogas Production, Journal Applied Energy, 93, 648-654.

Wu, T. Y., Mohammad, A. W., Jahim, J. Md., & Anuar N. (2010).[19Pollution control technologies for the treatment of palm oil mill effluent ]

(POME) through end-of-pipe processes[. 34Journal of Environmental Management] , 91, 1467-1490.

Lam, M.K., & Lee K.T. (2011).[19Renewable and sustainable bioenergies production from palm oil mill effluent (POME] ): [33Win–win strategies]

toward better environmental protection.Journal Biotechnology Advances, 29, 124–141.

Hosseini, S.E., & Wahid, M.A. (2013).[18Feasibility study of biogas production and utilization as a source of renewable energy in Malaysia] . [19]

Journal Renewable and Sustainable Energy Reviews, 19, 454–462.

Stamatelatou, K., Antonopoulou, G., & Lyberatos, G. (2011). Production of Biogas Via Anaerobic Digestion. Greece: Woodhead.

Yingyuad, R. (2007). Selection of Biogas Production System for Tapioca Starch Wastewater by Using Analytic Hierarchy Process. Thailand: Shinawatra University.

Seadi, T.A., Rutz, D., Prassl, H., Kottner, M., Finsterwalder, T., Volk, S., & Janssen, R. (2008). Biogas Handbook. Esbjerg:[34University of ]

Southern Denmark.

Olvera, J.R., & Lopez, A.L (2012). Biogas Production from Anaerobic Treatment of Agro-Industrial Wastewater. Rijeka: Intech.

Jung, J.Y., Lee, S.M., Shin, P.K., Chung, Y.C. (2000). Effect of pH on Phase Separated Anaerobic Digestion. Biotechnology Bioprocess Engineering, 5, 456-459.

Wong, Yee Shian., Teng, T.T., Ong, Soon-An., Norhashimah, M., Rafatulloh, M., & Lee, Hong-Chen. (2013).[31Anaerobic acidogenesis ]

biodegradation of palm oil mill effluent using Suspended Closed Anaerobic Bioreactor (SCABR) at mesophilic temperatur. [36Procedia]

Environmental Sciences,18, 433-441.

(11)

Veeken, A., Kalyuzhnyi, S., Scharff, H., Hamelers, B. (2000). Effect of pH and VFA on Hydrolysis of Organic Solid Waste.[42Journal of ]

Environmental Engineering, 126, 1076 – 1081.

Polprasert, Chongrak. (2007). Organic Waste – Recycling. London: Iwa Publishing.

Zinatizadeh, A.A.L., Mohamed, A.R., Najafpour, G.D., Isa, M.H., Nasrollahzadeh, H. (2006). Kinetic Evaluation of Palm Oil Mill Effluent Digestion in a High Rate Up-flow Anaerobic Sludge Fixed Film Bioreactor. Process Biochemistry, 41,1038.

Salihu, A., & Alam, M.Z. (2012).[17Palm oil mill effluent] : a waste or a raw material?. Journal of Applied Sciences Research, 8, 466-473.

[50]

Li, W-W., & Yu, H-Q. (2011). From wastewater to bioenergy and biochemicals via two-stage bioconversion processes: A future paradigm.

Biotechnology Advances, 29, 972–982.

Blonskaja, V., Menert, A., & Vilu, R. (2003). Use of two-stage anaerobic treatment for distillery waste. Advances in Environmental Research, 7, 671–678.

Demirer, G.N., & Chen, S. (2005). Two-phase anaerobic digestion of unscreened dairy manure. Process Biochemistry. 40, 3542–3549. He, M., Sun, Y., Zou, D., Yuan, H., Zhu, B., Li, X., & Pang, Y. (2012).

㻌

Influence of temperature on hydrolysis acidification of food waste.

Procedia Environmental Sciences, 16, 85 – 94.

Solera, R., Romero, L.I., & Sales, D. (2002).[47The Evolution of Biomass in a] Two-Phase Anaerobic Treatment Process During Start-up.

Biochemical Engineering, 16, 25–29.

Zhang, X.J. (2014). Anaerobic Process.United State: University of Massachusetts Lowell.

Fang, H.H.P. & Yu, H.Q. (2000). Effect of HRT on Mesophilic Acidogenesis of Dairy Wastewater.[42Journal of Environmental Engineering, ]

1145–1148.

Maharaj, I., & Elefsiniotis, P. (2001). The Role of HRT and Low Temperature on The Acid –Phase Anaerobic Digestion of Municipal and Industrial Wastewaters. Bioresources Technology, 76, 191–197.

SenthilKumar, M., Gnanapragasam, G., Arutchelvan, V., & Nagarajan, S. (2010). Influence of Hydraulic Retention Time in a Two-phase Upflow Anaerobic Sludge Blanket Reactor Treating Textile Dyeing Effluent Using Sago Effluent as the Co-substrate. Environ. Sci. Pollut. Res. 18, 649-654.

APHA. (1999).[17Standard Methods for the Examination of Water and Wastewater] . 20th edition. Washington DC: APHA, AWWA, WEF Schmit, K.H. & Ellis, T.G. (2001). Comparison of Temprature-Phased and Two-Phase Anaerobic Co-Digestion of Primary Sludge and Municipal

Solid Waste. Water Environment Research. 73, 314-321.

Li, J., Ban, Q., Zhang, L., & Kumar, JA. (2012), Syntrophic Propionate Degradation in Anaeoric Digestion: A Review.[55International Journal of ]