Analisis Kadar Kebutuhan Oksigen Kimiawi (KOK), Kebutuhan Oksigen Biologi dan Minyak Lemak pada Limbah Cair Pabrik Kelapa Sawit

(1)

iv ANALISIS KADAR KEBUTUHAN OKSIGEN KIMIAWI (KOK),

KEBUTUHAN OKSIGEN BIOLOGI (KOB), MINYAK/LEMAK PADA LIMBAH CAIR PABRIK KELAPA SAWIT

ABSTRAK

Analisis yang telah dilakukan untuk menentukan kadar Kebutuhan Oksigen Kimiawi dan Kebutuhan Oksigen Biologi dengan metode titrasi, Minyak/Lemak dengan motode ekstraksi-gravimetri pada Limabah Cair Pabrik Kelapa Sawit. Dengan melakukan pemanasan selama 2 jam pada suhu 150o_{C dilakukan pada}

COD Destruction Block lalu dititrasi diperoleh kadar KOK pabrik A sebanyak 96,384 mg/L, pabrik B sebanyak 144,576 mg/L, pabrik C sebanyak 160,64 mg/L, dengan melakukan inkubasi lalu dititrasi diperoleh kadar KOB pabrik A sebanyak 0,4 mg/L dengan pengenceran 500 kali, pabrik B sebanyak C sebanyak 0,4 mg/L dengan pengenceran 1000 kali, dengan melakukan pengeringan, ekstraksi dan penimbangan diperoleh kadar Minyak/Lemak pabrik A sebanyak 19 mg/L, pabrik B sebanyak 14 mg/L, pabrik C sebanyak 71 mg/L. Dari hasil diatas diperoleh kadar KOK, KOB dan Minyak/Lemak pabrik A dan B memenuhi baku mutu, sedangkan pabrik C kadar KOK dan KOB memenuhi baku mutu, tetapi kadar Minyak/Lemak tidak memenuhi baku mutu yang ditetapkan oleh

Permen/LH/5/2014 tentang Baku Mutu Air Limbah.

Kata kunci : KOK, KOB, Minyak/Lemak

(2)

v ANALYSIS OF CHEMICAL OXYGEN DEMAND (COD),

BIOLOGICAL OXYGEN DEMAND (BOD) AND OIL/FAT IN PALM OIL MILL EFFLUENT

ABSTRACT

Analyses have been performed to determine the level of Chemical Oxygen Demand and Biological Oxygen Demand by titration method, Oil / Fat with gravimetric extraction-method on Liquid Fluid of Palm Oil Factory. By heating for 2 hours at temperature 150o_{C done at COD Destruction Block then dititrasi}

obtained COD A plant amounting to 96,384 mg / L, factory B as much 144,576 mg / L, factory C as much 160,64 mg / L, by incubation and then titrated Obtained A plant BOD content of 0.4 mg / L with dilution 500 times, factory B of C as much as 0.4 mg / L with dilution 1000 times, by drying, extracting and weighing obtained Oil / A plant oil content of 19 mg / L, plant B as much as 14 mg / L, factory C as much as 71 mg / L. From the above results, COD, BOD and Oil / Fat content of factory A and B meet the quality standard, while the C plant content of COD and BOD meet the quality standard, but the oil / fat content does not meet the quality standard set by Permen / LH / 5/2014 On Wastewater Quality

Standards.

Keywords : COD, BOD, Oil/Fat