1
ANDHRA PRADESH POLLUTION CONTROL BOARD ZONAL OFFICE, VIJAYAWADA
Agenda for CFE Committee meeting
Date : 16.09.2019 CFE AGENDA ITEM NO: 04 Single Desk/OCMMS last date:- 20.09.2019
01) Name of the Industry &
Location address with Sy.Nos. : M/s. Sandhya Aqua Exports Pvt. Ltd., S.No.819/9B,819/10, Perikegudem (V), Mandavalli (M),
Krishna District.
i) Longitude : --
ii) Latitude : --
iii) Address for correspondence with
pin code Flat No : 207 , A1 Block , Venkataram Grand
Apartments ,Near Ramapuram Colony , Poranki , Vijayawada,
Krishna District.
02) Inspection details :
i) Date of application 19.08.2019 & 28.08.2019
i) Date of inspection 06.09.2019
ii) Inspection conducted by AEE-II, RO, VJA iii) Name of representative of the
industry present, cell no and mail ID.
: Sri. Hari Krishna Kunam 9963968886
03) Project site details: :
i) Total area of the land : 2.06 acres
ii) Built up area : 0.244 acres
iii) Greenery : --
iv) Nearest Human habitation : Village habitations are existing at a distance of about 18 meters on the other side of the irrigation drain located on West direction of the proposed industry. Residential buildings of Perikegudem village are existing at about 50 meters from the boundary of the proposed industry premises.
v) Nearby water body : --
vi) Surroundings of the site North : Agricultural lands South : Irrigation canal East : Approach road
West : Vacant land followed by drain exists at about 10 mtrs from the boundary of the proposed site of the industry.
vii) Road details
04) Project Cost : Rs.300.0 lakhs
05) CFE fee details : Receipt No: 719897084, Rs.18000/- Dt.10-05-2019.
CFE Fee:
Category of the industry
Capital investment
% fee & fee to be paid under one Act.
Minimum fee to be paid under both acts.
Fee to be paid under both acts
Total fee payable
Amount paid
Balance fee to be paid/
Excess paid Orange
(Haz) Rs.300.0
lakhs 0.030% =
Rs.9000/- Rs.
7500/- Rs.
18000/- Rs.
18000/- Rs.
18000/- -- 06) i) Category of the Industry : Orange-Haz
ii) Line of activity as per the list
communicated by the CPCB : Primary pre-processing of shrimp facility.
2 07) Products and By-products: :
Sl.
No. Name of the Products and By-products Proposed
capacity
1 De-Headed Shrimp 6.5 TPD
08) Raw material and chemicals used : :
Sl. No. Name of the Raw materials and chemicals Quantity
1 Raw Shrimp 10 TPD
09) Brief description of process : Flow diagram with description of process is enclosed.
10) Source of Water supply : Ground water 11) Water Pollution, treatment and disposal :
A) water consumption:
B) Waste Water Generation :
Effluent source Treatment proposed Mode of disposal Washing
Domestic Septic tank Septic tank followed by soak pit 12) Air Emissions, control systems:
Sl.No Details of Stack Stack No. 1
a) Attached to: DG set
b) Capacity 1 x 63 KVA
c) Name of the Fuel : Diesel
d) Stack height above ground (m.) 1.5 mtrs
e) Air Pollution Control Equipment: Accoustic enclosures.
f) Conc. of particulate matter mg/Nm3 --
13) Solid Waste and its disposal:
Hazardous Waste:
S.
No. Name of the Solid
Waste Non – Hazardous Quantity of Hazardous
waste
Disposal Option
1. Used Oil 5.1 of Schedule – I 200 LPA Proposed to dispose to Authorized waste oil re- processors.
Non – Hazardous Waste:
S.
No. Name of the Solid
Waste Non – Hazardous Quantity of Hazardous
waste
Disposal Option
1. Head and Shell Waste -- 3.5 TPD Disposal to poultry feed
manufacturing units.
14) Court cases / complaints, if any. :
Sl. No. Source Quantity (KLD)
a) Washing 30
b) Cooling 10
c) Domestic 10
Total 50
Sl. No. Source Quantity (KLD)
a) Washing 30
b) Cooling bleed-off 5
B) Domestic 8
Total 43
3 15) Inspection Officer’s Remarks:
1) The proposal of M/s. Sandhya Aqua Exports Pvt. Ltd., at Sy.No.819/9B,819/10, Perikegudem (V), Mandavalli (M), Krishna District is for establishment of Primary pre-processing unit in which De-heading and de-veining of Shrimp – 6.5 Tons/day with total investment of Rs.300.0 Lakhs which comes under orange category.
2) The project proponent had applied for CFE of the Board and same was rejected by Zonal office, Vijayawada for the following reasons:
i) As the industry is in close proximity to habitation i.e., 18 mtrs, ii) Water and air problems are well anticipated,
iii) sufficient land is not available for land application of treated effluent,
iv) Not proposed any treatment for domestic effluent of 14.4 KLD (320 workers) and v) The industry is discharging untreated effluent into the abutting drain vide ZO rejection
Lr.dt.31.05.2019.
3) It was observed that the pre-processing activities are in full swing generating waste water from the processing activity and hence, the issue of CFE of the Board does not arise as the industry has come-up for production.
4) The site of the industry is existing in close proximity of about 18 mtrs from the village habitations of Perikegudem(V) on West direction and also located at a distance of about 50 mtrs from the Northern boundary of the industry. Water and air pollution problems are well anticipated due to the operations of the industry. This issue may be examined.
5) The industry already constructed ETP with the designed capacity of 50 KLD which consists of bar screen chamber, effluent collection tank, the vertical and rectangular clarifier, chemical dosing tank, 4 stage secondary clarifier, treated waste water collection tank, Multi-grade sand filter and activated carbon filtration system. The industry need to acquire additional land as per the stipulated Board’s norm of 1 Acre @ of utilizing every 10 KLD of treated waste water that generates from process, for on land applications.
6) It was observed that at about 320 workers are working in the industry premises.
7) The industry is provided with a water storage tank with size of about 162 ft x105 ft x 5 ft at the front portion of the industry premises which is now empty.
8) The industry installed a tube type ice blocks making unit with installed capacity of 20 TPD for which Ammonia storage tank of 20 Tonnes capacity is provided.
9) The industry shall dispose waste oil from DG set to the authorized waste oil recycling units only.
10) Peelings and veins of about 3.5 TPD would be generated as solid waste, it was informed that they are sending this waste to chitin manufacturing units.
11) The Issue of CFE may not be considered to the project proponent as the earlier CFE application was already rejected and there is no change in location and the project activities.
16) Regional Officer’s Remarks:
The CFE application may be rejected, as the unit already established and continuing production activity. The location of the unit is close to human habitation.
17) ZO Remarks:
Previously the Zonal Office, Vijayawada rejected the CFE application submitted by the industry on 31.05.2019. Now the industry applied (resubmitted) to obtain CFE of the Board.
The matter is placed before the CFE committee for review and to take a decision.
@@ @@ @@
